DVLA recall archive
The archive holds 15,570 DVLA vehicle safety recalls dating back to 1992. Filter by manufacturer, year, or keyword. To check whether a specific vehicle is affected by an outstanding recall, run a live VRM recall check for £1.99.
Showing 1901–1925 of 15,570 recalls.
AJ21-D4 Turbo Oil Feed Pipe Leak
Affected vehicles have a Turbocharger oil feed pipe that may over time loosen and lead to an oil leak
Replace the Turbocharger oil feed pipe O-rings and install an additional clamp.
C0367 HPCU SW UPDATE FHE FME4
There is a risk that some screw joints inside the traction voltage batteries might not have been tightened according to our assembly process.
Update a software that can detect potential loose screw joints. It will then disconnect the suspect battery and prevent any incident.
C0367 HPCU SW UPDATE FHE FME4
There is a risk that some screw joints inside the traction voltage batteries might not have been tightened according to our assembly process.
Update a software that can detect potential loose screw joints. It will then disconnect the suspect battery and prevent any incident.
C0367 HPCU SW UPDATE FHE FME4
There is a risk that some screw joints inside the traction voltage batteries might not have been tightened according to our assembly process.
Update a software that can detect potential loose screw joints. It will then disconnect the suspect battery and prevent any incident.
Longitudinal Chassis Beam
On affected vehicles during production excessive force may have been applied to the rear left hand side chassis longitudinal beam which could lead to it cracking and affecting its structural strength.
On affected vehicles the rear left hand side chassis longitudinal beam will be checked and if necessary replaced.
SCR (Selective Catalytic Reduction) Diagnosis issues
Affected vehicles may have been equipped with Engine Control Unit (ECU) software not fulfilling regulation requirements.
Update to the ECU software.
Focus Lane Centering Assist Software Update
A number of Focus vehicles have been identified where the warning chimes may not be operating as intended. The chimes may not be audible when the driver is not holding the steering wheel for longer than 30 seconds while using Lane Centering Assist which does not meet ECE regulations.
Updating software in control unit.
Checking brake lines
On affected vehicles the bolts for the brake pressure lines may have been tightened too far. In such cases the bolted connection may fail resulting in brake fluid escaping.
Check the bolted connection and replace the brake pressure lines if required.
Power cable chafing
On affected vehicles power cables may chafe on the edge of an encapsulation plate due to edge protecting material might not have been correctly installed resulting in a potential risk of a short circuit and a consequential risk of a thermal event.
Check and adjust cable routing as necessary add rubber protection moulding as required.
Juke (F16) Qashqai (J12) and Leaf (ZE1) VIN Scan
On affected vehicles the VIN stored in the vehicle system may not match the actual VIN of the vehicle. This may lead to a situation where a vehicle user can see information related to a different vehicle resulting in a data security breach.
Replace the navigation display / control unit and the telematics control unit.
Audio Head Unit Replacement on Certain Aygo X
Affected vehicles are equipped with an audio head unit which has map data and speed limit information which are used as an input for the ISA (Intelligent Speed Assistance). Due to inappropriate software there is a possibility that the audio head unit display turns black and the unit stops working. If this condition occurs the rear camera image is not displayed during reverse manoeuvres and the ISA function does not work. As a result the vehicles do not comply with EU regulations and the risk of an accident increases.
Replace the audio head unit.
Integrated Braking System
On affected vehicles an unexpected loss of hydraulic brake assistance may occur and may result in a different pedal behaviour under specific conditions an extended braking distance may be experienced and ABS/Stability control may be impaired
On the affected vehicles the Integrated Brake System will be replaced
Kia Stinger High Pressure Fuel Pump Recall
On affected vehicles misalignment of the fuel control valve plunger in the high pressure fuel pump can result in uneven wear. This may potentially result in loss of motive power and in some cases the check engine light may illuminate.
On affected vehicles the control software will be updated the high pressure fuel pump will be checked and if necessary replaced.
Juke (F16) Qashqai (J12) and Leaf (ZE1) VIN Scan
On affected vehicles the VIN stored in the vehicle system may not match the actual VIN of the vehicle. This may lead to a situation where a vehicle user can see information related to a different vehicle resulting in a data security breach.
Replace the navigation display / control unit and the telematics control unit.
Juke (F16) Qashqai (J12) and Leaf (ZE1) VIN Scan
On affected vehicles the VIN stored in the vehicle system may not match the actual VIN of the vehicle. This may lead to a situation where a vehicle user can see information related to a different vehicle resulting in a data security breach.
Replace the navigation display / control unit and the telematics control unit.
Replace Rear Door Panel
On affected vehicles the armrest on the rear door trim may not be secured to the correct specification which could damage side air bag during deployment
On affected vehicles the affected rear door trim will be replaced
High voltage emergency shutdown can be overridden by intelligent charging
On affected vehicles the high voltage emergency shutdown can be overridden by intelligent charging when low voltage batteries state of charge drops below a specific level.
Update drive module software and dashboard display software.
AJ20-D6 and AJ20-P6 Engine Oil Filter Housing Cracked
On affected vehicles the incorrect specification of plastic was used to manufacture the oil filter housing. This housing may over time and with vehicle use crack. This could result in oil under pressure leaking and coming into contact with hot components of the engine which may result in a fire. Additionally oil may leak onto the road surface posing a skid hazard.
Replace the oil filter housing complete with filter and associated O-rings.
AJ20-D6 and AJ20-P6 Engine Oil Filter Housing Cracked
On affected vehicles the incorrect specification of plastic was used to manufacture the oil filter housing. This housing may over time and with vehicle use crack. This could result in oil under pressure leaking and coming into contact with hot components of the engine which may result in a fire. Additionally oil may leak onto the road surface posing a skid hazard.
Replace the oil filter housing complete with filter and associated O-rings.
AJ20-D6 and AJ20-P6 Engine Oil Filter Housing Cracked
On affected vehicles the incorrect specification of plastic was used to manufacture the oil filter housing. This housing may over time and with vehicle use crack. This could result in oil under pressure leaking and coming into contact with hot components of the engine which may result in a fire. Additionally oil may leak onto the road surface posing a skid hazard.
Replace the oil filter housing complete with filter and associated O-rings.
AJ20-D6 and AJ20-P6 Engine Oil Filter Housing Cracked
On affected vehicles the incorrect specification of plastic was used to manufacture the oil filter housing. This housing may over time and with vehicle use crack. This could result in oil under pressure leaking and coming into contact with hot components of the engine which may result in a fire. Additionally oil may leak onto the road surface posing a skid hazard.
Replace the oil filter housing complete with filter and associated O-rings.
High voltage emergency shutdown can be overridden by intelligent charging
On affected vehicles the high voltage emergency shutdown can be overridden by intelligent charging when low voltage batteries state of charge drops below a specific level.
Update drive module software and dashboard display software.
AJ20-D6 and AJ20-P6 Engine Oil Filter Housing Cracked
On affected vehicles the incorrect specification of plastic was used to manufacture the oil filter housing. This housing may over time and with vehicle use crack. This could result in oil under pressure leaking and coming into contact with hot components of the engine which may result in a fire. Additionally oil may leak onto the road surface posing a skid hazard.
Replace the oil filter housing complete with filter and associated O-rings.
AJ20-D6 and AJ20-P6 Engine Oil Filter Housing Cracked
On affected vehicles the incorrect specification of plastic was used to manufacture the oil filter housing. This housing may over time and with vehicle use crack. This could result in oil under pressure leaking and coming into contact with hot components of the engine which may result in a fire. Additionally oil may leak onto the road surface posing a skid hazard.
Replace the oil filter housing complete with filter and associated O-rings.
High voltage emergency shutdown can be overridden by intelligent charging
On affected vehicles the high voltage emergency shutdown can be overridden by intelligent charging when low voltage batteries state of charge drops below a specific level.
Update drive module software and dashboard display software.
The DVLA archive lists recalls by make and model. Run a live VRM check to see whether your vehicle has an outstanding recall right now.
Run a recall check for £1.99 →